Print This Page

Bowl & Porcelain Cleaner

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

BOWL & PORCELAIN CLEANER

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS CAS# APPROX% ACGIH-TLV  OSHA-PEL
HYDROCHLORIC ACID 7647-01-0 1-5% 5 ppm 5 ppm
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS's that are copied and distributed for this material.

SHIPPING INFORMATION

CONSUMER COMMODITY ORM-D

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 1 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT  B 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

OPAQUE, BLUE LIQUID

 		ODOR

PLEASANTLY SCENTED

 		BOILING POINT

212 F
SPECIFIC GRAVITY (H2O=1)

1.02

 		VAPOR PRESSURE (mm Hg.)

18

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

<1

 EVAPORATION RATE (BUAC=1)

<1

 		SOLUBILITY IN WATER

COMPLETE

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
NONE (PERCENT BY VOLUME) N/A N/A
FIRE EXTINGUISHING MEDIA

WATER.
SPECIAL FIRE FIGHTING PROCEDURES

HYDROGEN CHLORIDE GAS MAY BE RELEASED IF PRODUCT IS HEATED. USE A GAS MASK.
UNUSUAL FIRE AND EXPLOSION HAZARD

HCL FUMES REACT WITH MOST COMMON METALS TO PRODUCE HYDROGEN GAS WHICH CAN BE A FIRE AND/OR EXPLOSION HAZARD.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY ______Inhalation __X___Skin contact ______Eye contact __X___Ingestion
EFFECT OF OVEREXPOSURE

EYES: MAY IRRITATE EYES.

SKIN: MAY IRRITATE SKIN.

INGESTION: MAY IRRITATE GASTROINTESTINAL TRACT AND AFFECT OTHER INTERNAL ORGANS.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

UNKNOWN.
EMERGENCY AND FIRST AID PROCEDURES

QUICKLY FOLLOW DIRECTIONS BELOW; CALL A POISON CONTROL CENTER OR PHYSICIAN. GET QUICK   MEDICAL ATTENTION IF ANY ILL EFFECTS CONTINUE TO DEVELOP LATER.

EYES: FLUSH EYES WITH PLENTY OF WATER WHILE REMOVING ANY CONTACT LENSES, THEN HOLD EYELIDS OPEN AND CONTINUE FLUSHING THOROUGHLY.

SKIN: REMOVE ANY CONTAMINATED CLOTHING, THEN WASH AFFECTED SKIN WITH SOAP AND WATER.

INGESTION: RINSE MOUTH WITH WATER, SPIT OUT RINSE, THEN DRINK A GLASSFUL OF WATER. DO NOT INDUCE VOMITING UNLESS DIRECTED BY MEDICAL PERSONNEL.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X AVOID HEATING TO ABNORMAL TEMPERATURES.
INCOMPATIBILITY (MATERIALS TO AVOID)
AVOID STRONGLY CAUSTIC MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS
HCL AND OXIDES OF CARBON AND SULFUR MAY BE FORMED UPON COMBUSTION.
HAZARDOUS
POLYMERIZATION		 MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

WIPE OR MOP UP SPILLS, THEN RINSE WITH WATER.
WASTE DISPOSAL METHOD

WASTE, INCLUDING SPILLS OR RINSEATES AND LEFTOVER PRODUCT THAT CANNOT BE USED ACCORDING TO APPLICABLE FEDERAL, STATE AND LOCAL REQUIREMENTS. EMPTY CONTAINERS SHOULD BE DISPOSED OF PER LABEL DIRECTIONS, IN THE TRASH, OR OFFERED FOR RECYCLING IF ALLOWED BY FEDERAL, STATE, AND LOCAL REQUIREMENTS.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

NONE REQUIRED.
VENTILATION

MECHANICAL - ADEQUATE VENTILATION.
PROTECTIVE GLOVES

RUBBER OR PLASTIC

 		EYE PROTECTION

SAFETY GLASSES
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

N/A

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

CAUTION - MAY IRRITATE EYE OR SKIN. AVOID CONTACT WITH EYES OR SKIN. KEEP OUT OF REACH OF CHILDREN. STORE IN A COOL, DRY AREA. DO NOT TAKE INTERNALLY.
OTHER PRECAUTIONS

READ AND FOLLOW LABEL DIRECTIONS.
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.