Print This Page

Freeze - Guard

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name
Freeze - Guard

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS CAS# APPROX% ACGIH-TLV OSHA-PEL
PROPYLENE GLYCOL 000057-55-6 35% --------- -------
DIPOTASSIUM PHOSPHATE 007758-11-4 <5% --------- -------
WATER 007732-18-5 60% --------- -------

THIS PRODUCT IS NOT CLASSIFIED AS HAZARDOUS IN ACCORDANCE WITH OSHA 1910.1200.
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIPPING PURPOSES.

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 0 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT A 4- SEVERE

ECTION III - PHYSICAL DATA
APPEARANCE

RED DYE, SLIGHTLY VISCOUS

 		ODOR

RELATIVELY ODORLESS

 		BOILING POINT

370° F, 188° C
SPECIFIC GRAVITY (H2O=1)

1.050@60/60° F, 16° C

 		VAPOR PRESSURE (mm Hg.)

0.22 mmHG@20° C, 68° F

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

2.62

 EVAPORATION RATE (BUAC=1)

N/A

 		SOLUBILITY IN WATER

COMPLETE

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
215° F, 102° C (PERCENT BY VOLUME) 2.0% 13.0%
FIRE EXTINGUISHING MEDIA

DRY CHEMICAL, WATERSPRAY, WATER FOG, CO2, OR ALCOHOL TYPE FOAM.
SPECIAL FIRE FIGHTING PROCEDURE

DO NOT ENTER FIRE AREA WITHOUT PROPER PROTECTION. FIGHT FIRE FROM DISTANCE/PROTECTED LOCATION. HEAT MAY BUILD PRESSURE AND RUPTURE CLOSED CONTAINERS.` USE WATER SPRAY/FOG FOR COOLING. AVOID FROTHING/STEAM EXPLOSION.

BURNING LIQUID MAY FLOAT ON WATER. ALTHOUGH SOLUBLE, MAY NOT BE PRACTICAL TO EXTINGUISH FIRE BY WATER DILUTION. NOTIFY AUTHORITIES IF LIQUID ENTERS SEWER/PUBLIC WATERS.
UNUSUAL FIRE AND EXPLOSION HAZARD

HEAT FROM FIRE CAN GENERATE FLAMMABLE VAPOR. WHEN MIXED WITH AIR AND EXPOSED TO IGNITION SOURCE, VAPORS CAN BURN IN OPEN OR EXPLODE IF CONFINED. VAPORS MAY BE HEAVIER THAN AIR. MAY TRAVEL LONG DISTANCES ALONG GROUND BEFORE IGNITING/FLASHING BACK TO VAPOR SOURCE. FINE SPRAYS/MISTS MAY BE COMBUSTIBLE AT TEMPERATURES BELOW NORMAL FLASH POINT.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY ______Inhalation ______Skin contact __X___Eye contact ______Ingestion
EFFECT OF OVEREXPOSURE

EYES: MAY CAUSE MINOR EYE IRRITATION.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

NONE
EMERGENCY AND FIRST AID PROCEDURES

EYES: IN CASE OF EYE CONTACT, IMMEDIATELY RINSE WITH CLEAN WATER FOR 20-30 MINUTES. RETRACT EYELIDS OFTEN. OBTAIN EMERGENCY MEDICAL ATTENTION IF PAIN, BLINKING, TEARS, OR REDNESS PERSIST.

SKIN, INGESTION & INHALATION: NOT EXPECTED TO PRESENT A SIGNIFICANT INGESTION HAZARD UNDER ANTICIPATED CONDITIONS OF NORMAL USE.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X NONE
INCOMPATIBILITY (MATERIALS TO AVOID)
STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS
INCOMPLETE COMBUSTION MAY PRODUCE CARBON MONOXIDE AND OTHER HARMFUL GASES/VAPORS,

INCLUDING OXIDES OF PHOSPHOROUS AND POTASSIUM.
HAZARDOUS
POLYMERIZATION		 MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

SLIPPERY - SPREAD GRANULAR COVER. IMPOUND/RECOVER LARGE LAND SPILL; SOAK UP SMALL SPILL ON WATER, MATERIAL SOLUBLE. CONTAIN/MINIMIZE DISPERSION/COLLECT. HIGHLY BIODEGRADABLE - CAN STIMULATE ALGAE GROWTH WHEN NOT PROPERLY INHIBITED.
WASTE DISPOSAL METHOD

CONTAMINATED PRODUCT/SOIL/WATER SHOULD BE CONSIDERED DANGEROUS DUE TO POTENTIAL FOR ENVIRONMENTAL HARM. LANDFILL SOLIDS AT PERMITTED SITES. USE REGISTERED TRANSPORTERS.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

NO SPECIAL RESPIRATORY PROTECTION EQUIPMENT IS RECOMMENDED UNDER ANTICIPATED CONDITIONS OF NORMAL USE WITH ADEQUATE VENTILATION.
VENTILATION

AT ELEVATED TEMPERATURES, SPECIAL VENTILATION MAY BE REQUIRED.
PROTECTIVE GLOVES

NONE

 		EYE PROTECTION

SPLASH GOGGLES AND FACE SHIELD
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

NONE

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

STORE IN TIGHTLY CLOSED CONTAINERS. STORE AWAY FROM HEAT/MOISTURE/STRONG OXIDIZING AGENTS. MATERIAL CAN ATTACK SOME FORMS OF PLASTICS. WHEN NORMAL HANDLING REQUIRES HEATING, DO NOT HEAT HIGHER THAN 50° F BELOW FLASH POINT UNLESS IN CLOSED SYSTEM AWAY FROM AIR. HANDLE EMPTY CONTAINERS WITH CARE/RESIDUE CAN BURN IF HEATED. DRAIN ANY NECESSARY RESIDUE TO SEWER CAREFULLY TO PREVENT UPSET TO SEWAGE TREATMENT.
OTHER PRECAUTIONS

NONE
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.