Print This Page

Impact

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

IMPACT

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS CAS# APPROX% ACGIH-TLV OSHA-PEL
D-LIMONENE 5989-27-5 25.00 N/E N/E
DIETHYLENE GLYCOL BUTYL ETHER 000112-34-5 6.00 N/E N/E
DIETHANOLAMINE 000111-42-2 2.00 3.000 ppm N
COCAMIDE DEA 68603-42-9 16.00 N/E N/E
TETRAPOTASSIUM PYROHOSPHATE 7320-34-5 2.00 N/E N/E

(Y = YES N = NO N/E = NOT ESTABLISHED)

*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS's that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIPPING PURPOSES.

SPECIAL HAZARD DESIGNATIONS

HMIS   HAZARD RATING
HEALTH 1 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 0 3- SERIOUS
EQUIPMENT   4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

YELLOW LIQUID

 		ODOR

CITRUS
BOILING POINT

212° F
SPECIFIC GRAVITY (H2O=1)

 .965

 		VAPOR PRESSURE (mm Hg.)

0.6

 		VOLATILE BY VOLUME (%)

27%
VAPOR DENSITY (AIR=1)

1>

 		EVAPORATION RATE (BUAC=1)

< 1

 		SOLUBILITY IN WATER

INFINITE

SECTION IV - FIRE AND EXPLOSION HAZARD DATA

FLASH POINT ( METHOD USED)

 FLAMMABLE LIMITS LEL UEL

140° F C.O.C.

 (PERCENT BY VOLUME) 1.1 10.6
FIRE EXTINGUISHING MEDIA

USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIRE FIGHTING PROCEDURE

WARNING. COMBUSTIBLE. CLEAR FIRE AREA OF UNPROTECTED PERSONNEL. DO NOT ENTER

CONFINED FIRE SPACE WITHOUT HELMET, FACE SHIELD, BUNKER COAT, GLOVES, RUBBER BOOTS,

AND A POSITIVE PRESSURE NOISH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARD

CONTAINERS EXPOSED TO INTENSE HEAT FROM FIRES SHOULD BE COOLED WITH WATER TO PREVENT

VAPOR PRESSURE BUILD-UP WHICH COULD RESULT IN CONTAINER RUPTURE. CONTAINERS THAT

ARE EXPOSED TO DIRECT FLAME SHOULD BE COOLED WITH WATER TO ELIMINATE STRUCTURAL

WEAKENING OF THE CONTAINER’S WALL AND POSSIBLE RUPTURE.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY __X_Inhalation ___X_Skin contact ___Eye contact ___Ingestion 
EFFECT OF OVEREXPOSURE

EYE CONTACT - EXTREMELY IRRITATING TO EYES. MAY CAUSE CORNEAL INJURY.

SKIN CONTACT - MAY CAUSE SKIN RASH.

INHALATION - MAY CAUSE MILD INTOXICATION. VAPORS IN HIGH CONCENTRATION WILL IRRITATE EYES AND UPPER RESPIRATORY SYSTEM.

INGESTION - MAY CAUSE BURNS TO GASTROINTESTIONAL TRACT.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

PREEXISTING SKIN, EYE AND RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE

TO THIS PRODUCT. IMPAIRED LIVER FUNCTIONS FROM PREEXISTING DISORDERS MAY BE AGGRAVATED

BY EXPOSURE TO THIS PRODUCT.
EMERGENCY AND FIRST AID PROCEDURES

EYES - IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES AND GET MEDICAL ATTENTION.

SKIN - WASH EXPOSED AREA THOROUGHLY WITH SOAP AND WATER.

INHALATION - REMOVE VICTIM TO FRESH AIR.

INGESTION - HAVE VICTIM DRINK TWO GLASSES OF WATER OR MILK TO DILUTE THE PRODUCT. DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION. NOTE: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING VICTIM.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X HEAT, OPEN FLAME

INCOMPATIBILITY (MATERIALS TO AVOID)
STRONG OXIDIZING AGENTS.

HAZARDOUS DECOMPOSITION PRODUCTS

OXIDES AND COMPOUNDS OF NITROGEN, CARBON DIOXIDE, CARBON MONOXIDE AND UNIDENTIFIED

ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
HAZARDOUS POLYMERIZATION MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE 

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

FLUSH WITH WATER INTO RETAINING AREA OR CONTAINER. AVOID EXPOSURE TO SPARKS, FIRE OR HOT METAL.
WASTE DISPOSAL METHOD

INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

USE VENTILATION AS REQUIRED TO CONTROL VAPOR CONCENTRATIONS - AT LEAST 10 AIR CHANGES PER HOUR ARE RECOMMENDED FOR GOOD GENERAL ROOM VENTILATION. IF EXPOSURE EXCEEDS THE

PEL/TLV, USE THE APPROPRIATE NIOSH-APPROVED RESPIRATOR.
VENTILATION

LOCAL EXHAUST
PROTECTIVE GLOVES

YES

 		EYE PROTECTION

YES
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

EYE WASH FOUNTAINS AND SAFETY SHOWERS SHOULD BE AVAILABLE FOR USE IN AN EMERGENCY

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. USE WITH ADEQUATE VENTILATION.
OTHER PRECAUTIONS

AVOID PROLONGED OR REPEATED CONTACT WITH SKIN
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.