Print This Page

Liquid Boiler Cleaner

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

 

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

LIQUID BOILER CLEANER

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS        CAS#             APPROX%            ACGIH-TLV                 OSHA-PEL
THIS PRODUCT IS NOT CLASSIFIED AS HAZARDOUS IN ACCORDANCE WITH OSHA 1910.1200.

 

*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS's that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIPPING PURPOSES.

 

 

 

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 1 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT  B 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

GREEN

 		ODOR

ODORLESS

 		BOILING POINT

214° F
SPECIFIC GRAVITY (H2O=1)

1.4

 		VAPOR PRESSURE (mm Hg.)

APPROX. 17

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

APPROX. 16

 		EVAPORATION RATE (BUAC=1)

>1

 		SOLUBILITY IN WATER

SOLUBLE

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
N/A (PERCENT BY VOLUME) N/A N/A
FIRE EXTINGUISHING MEDIA

USE PROPER EXTINGUISHER FOR SURROUNDING FIRE.

 
SPECIAL FIRE FIGHTING PROCEDURES

NORMAL FOR SURROUNDINGS.
UNUSUAL FIRE AND EXPLOSION HAZARD

NONE

 

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY _____Inhalation __X___Skin contact ______Eye contact __X___Ingestion

 

EFFECT OF OVEREXPOSURE

EYES: MIST OR SPRAY MAY BE IRRITATING TO EYES.

SKIN: MIST OR SPRAY MAY BE IRRITATING.

INHALATION: MAY IRRITATE MUCOUS MEMBRANES OF THE RESPIRATORY TRACT.

INGESTION: MAY IRRITAE ESOPHAGUS AND STOMACH
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

NONE KNOWN.

 
EMERGENCY AND FIRST AID PROCEDURES

EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.

INHALATION: GET PERSON OUT OF AREA TO FRESH AIR.

INGESTION: DO NOT INDUCE VOMITING.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X NONE
INCOMPATIBILITY (MATERIALS TO AVOID)
DO NOT MIX WITH ETHYLENE GLYCOL SOLUTIONS.
HAZARDOUS DECOMPOSITION PRODUCTS
NONE
HAZARDOUS POLYMERIZATION MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

STOP LEAK AND TRY TO REPLACE INTO CONTAINER. FLUSH SPILL AREA WITH WATER.
WASTE DISPOSAL METHOD

NON-HAZARDOUS LANDFILL.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

USE A NIOSH/MSHA APPROVED RESPIRATOR WHEN MIST IS MADE.
VENTILATION

NONE
PROTECTIVE GLOVES

RUBBER GLOVES

 		EYE PROTECTION

FACE SHIELD OR CHEMICAL GOGGLES
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

STANDARD WORK CLOTHING.

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

DO NOT STORE IN ALUMINUM CONTAINERS. DO NOT PLACE IN CONTACT WITH ACIDS.
OTHER PRECAUTIONS

PLACE LIDS ON CONTAINERS WHEN NOT IN USE.
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.