Print This Page

Liquid Boiler Stop-Leak

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

 

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

LIQUID BOILER STOP-LEAK

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS                 CAS#      APPROX%        ACGIH-TLV         OSHA-PEL
THIS PRODUCT IS NOT CLASSIFIED AS HAZARDOUS IN ACCORDANCE WITH OSHA 1910.1200.
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIPPING PURPOSES.

 

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 0 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT A 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

BLACK LIQUID

 		ODOR

SLIGHT

 		BOILING POINT

214° F
SPECIFIC GRAVITY (H2O=1)

1.2

 		VAPOR PRESSURE (mm Hg.)

N/A

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

N/A

 

 EVAPORATION RATE (BUAC=1)

N/A

 		SOLUBILITY IN WATER

SOLUBLE

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
N/A (PERCENT BY VOLUME) N/A N/A
FIRE EXTINGUISHING MEDIA

USE EXTINGUISHING MEDIA APPROPRIATE TO IGNITION SOURCE OF FIRE.
SPECIAL FIRE FIGHTING PROCEDURES

NONE
UNUSUAL FIRE AND EXPLOSION HAZARD

NONE.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY ______Inhalation __X___Skin contact __X___Eye contact __X___Ingestion

 

EFFECT OF OVEREXPOSURE

EYE CONTACT: CAUSES IRRITATION.

SKIN CONTACT: CAUSES IRRITATION.

INGESTION: CAUSES IRRITATION TO ESOPHAGUS AND STOMACH.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

NONE KNOWN.
EMERGENCY AND FIRST AID PROCEDURES

EYES: FLUSH WITH WATER FOR 15 MINUTES.

SKIN: FLUSH WITH PLENTY OF WATER.

INGESTION: GIVE LARGE QUANTITIES OF WATER OR MILK. DO NOT INDUCE VOMITING.

IN ALL CASES CALL A PHYSICIAN.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X NONE.
INCOMPATIBILITY (MATERIALS TO AVOID)
DO NOT MIX WITH ACIDS.
HAZARDOUS DECOMPOSITION PRODUCTS
NONE
HAZARDOUS
POLYMERIZATION		 MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE.

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

REPLACE INTO CONTAINER. NON-HAZARDOUS LANDFILL IF NECESSARY.
WASTE DISPOSAL METHOD

COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS. NON-HAZARDOUS LANDFILL.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

USE A NIOSH/MSHA APPROVED RESPIRATOR WHEN MIST OR SPRAY IS PRESENT.
VENTILATION

NONE
PROTECTIVE GLOVES

RUBBER GLOVES

 		EYE PROTECTION

SAFETY GLASSES
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

NONE

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

KEEP OUT OF REACH OF CHILDREN.
OTHER PRECAUTIONS

NONE
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.