Print This Page

Liquid Build-Up Remover

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

LIQUID BUILD-UP REMOVER

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS CAS# APPROX% ACGIH-TLV OSHA-PEL
ETHOXYLATED ALKYLPHENOL 9016-45-9 3-5% N/A N/A
VIABLE BACTERIAL CULTURES  N/A GT 90% N/A N/A
(LARGELY WATER) 7732-18-5 N/A N/A

  
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

 

NOT HAZARDOUS FOR SHIPPING PURPOSES.

 

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 1 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT --- 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

WHITE TO OFF-WHITE OPAQUE LIQUID

 		ODOR

PERFUMED

 		BOILING POINT

100° C
SPECIFIC GRAVITY (H2O=1)

APPROXIMATELY 1.0

 		VAPOR PRESSURE (mm Hg.)

EQUIVALENT TO WATER

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

EQUIVALENT TO WATER

 

 EVAPORATION RATE (BUAC=1)

N/A

 		SOLUBILITY IN WATER

99%

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
N/A (PERCENT BY VOLUME) N/A N/A
FIRE EXTINGUISHING MEDIA

WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER.
SPECIAL FIRE FIGHTING PROCEDURES

NONE.
UNUSUAL FIRE AND EXPLOSION HAZARD

NONE.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY ______Inhalation ______Skin contact __X___Eye contact ______Ingestion
EFFECT OF OVEREXPOSURE

INGESTION: INGESTION MAY RESULT IN ABDOMINAL PAIN, NAUSEA AND VOMITING.

EYES: THIS MATERIAL MAY CAUSE EYE IRRITATION.

SKIN: CONTACT MAY CAUSE IRRITATION.

INHALATION: NONE KNOWN.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

MAY CAUSE INFECTION IF IN CONTACT WITH OPEN WOUNDS.
EMERGENCY AND FIRST AID PROCEDURES

SKIN: REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. WASH MATERIAL OFF THE SKIN WITH SOAP AND WATER. WASH CLOTHING AND FOOTWEAR BEFORE REUSE.

EYES: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES AND HAVE EYES EXAMINED AND TREATED BY MEDICAL PERSONNEL.

INGESTION: INDUCE VOMITING ONLY IF ADVISED BY PHYSICIAN OR POISON CONTROL CENTER.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X NONE
INCOMPATIBILITY (MATERIALS TO AVOID)
STRONG ACIDS OR ALKALI COMPOUNDS MAY INACTIVATE BIOLOGICAL CULTURES.
HAZARDOUS DECOMPOSITION PRODUCTS
NONE.
HAZARDOUS POLYMERIZATION MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

WHERE POSSIBLE, FLUSH DOWN DRAIN TO WASTE TREATMENT SEWER; OTHERWISE ON SMALL SPILLS, USE CHEMICAL ABSORBENT AND SWEEP UP. FOR LARGE SPILLS, CONTAIN AND COLLECT FOR REUSE OR DISPOSAL.
WASTE DISPOSAL METHOD

DISPOSAL OF THIS PRODUCT OR ITS RESIDUES MUST BE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REQUIREMENTS.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

NONE REQUIRED FOR RECOMMENDED USE. AVOID CREATING AEROSOLS IN POORLY VENTILATED AREAS.
VENTILATION

NORMAL ROOM VENTILATION.
PROTECTIVE GLOVES

N/A

 		EYE PROTECTION

SAFETY GLASSES
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

NONE.

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

PREVENT SKIN AND EYE CONTACT. WASH HANDS THOROUGHLY WITH SOAP AND WATER AFTER USE.

AVOID CONTACT WITH EYES.
OTHER PRECAUTIONS

NONE
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.