|
SECTION
I - GENERAL
INFORMATION
|
Black
Swan Manufacturing
Co.
4540
W. Thomas Street
Chicago,
IL 60651-3318
Telephone
No: 1-773-227-3700
Fax
No: 1-773-227-3705 |
For
chemical emergencies
during
transportation
only call
INFOTRAC
1-800-535-5053
24
hours per day - 7
days a week
|
| Date
Prepared
01/01/08
|
Trade
Name
LIQUID
FLUX
|
|
SECTION
II - HAZARDOUS
INGREDIENTS
/ IDENTITY
INFORMATION
|
| HAZARDOUS
COMPONENTS |
CAS# |
APPROX% |
ACGIH-TLV |
OSHA-PEL |
|
| ZINC
CHLORIDE |
7646-86-7 |
40% |
1
mg/m3 |
-------- |
| AMMONIUM
CHLORIDE |
12125-02-9 |
20% |
10
mg/m3 |
-------- |
|
*Title III Section
313 Supplier Notification: this product contains toxic
chemicals subject to the reporting requirements of Section
313 of the Emergency planning and community Right-to-Know
Act of 1966 and of 40CFR372. This information must be
included in all MSDS's that are copied and distributed
for this material. |
|
SHIPPING
INFORMATION
NOT
HAZARDOUS FOR SHIPPING
PURPOSES.
|
SPECIAL
HAZARD DESIGNATIONS
| HEALTH |
1 |
0
-
MINIMAL |
| FLAMMABILITY |
0 |
1-
SLIGHT |
| REACTIVITY |
0 |
2-
MODERATE |
| PROTECTIVE |
|
3-
SERIOUS |
| EQUIPMENT |
C |
4-
SEVERE |
|
|
SECTION
III - PHYSICAL
DATA
|
| APPEARANCE
CLEAR
TO BROWN
LIQUID
|
ODOR
WINTERGREEN
ODOR
|
BOILING
POINT
230° F
|
| SPECIFIC
GRAVITY (H2O=1)
1.403
|
VAPOR
PRESSURE (mm
Hg.)
N/E
|
VOLATILE
BY VOLUME (%)
N/E
|
| VAPOR
DENSITY (AIR=1)
N/E
|
EVAPORATION
RATE (BUAC=1)
<1
|
SOLUBILITY
IN WATER
100
|
|
SECTION
IV - FIRE AND
EXPLOSION HAZARD
DATA
|
| FLASH
POINT ( METHOD USED) |
FLAMMABLE
LIMITS |
LEL |
UEL |
| NON-FLAMMABLE |
(PERCENT
BY VOLUME) |
N/E |
N/E |
| FIRE
EXTINGUISHING
MEDIA
ALL
|
| SPECIAL
FIRE FIGHTING
PROCEDURES
NONE
|
| UNUSUAL
FIRE AND EXPLOSION
HAZARD
HYDROGEN
GAS MAY
EVOLVE
IN CONTACT
WITH
METAL.
|
|
SECTION
V - HEALTH
HAZARD DATA
|
| PRIMARY
ROUTES OR ENTRY __X___Inhalation
__X___Skin
contact ______Eye
contact __X___Ingestion |
| EFFECT
OF OVEREXPOSURE
ACID
TYPE
BURNS.
|
| MEDICAL
CONDITIONS
AGGRAVATED
BY EXPOSURE
SKIN
AND RESPIRATORY
CONDITIONS.
|
| EMERGENCY
AND FIRST AID
PROCEDURES
SKIN:
FLUSH
WITH
WATER
IMMEDIATELY.
SEEK
MEDICAL
ATTENTION.
EYES:
FLUSH WITH WATER
FOR 15 MINUTES. SEEK
MEDICAL ATTENTION.
INGESTION:
DRINK LARGE AMOUNTS
OF WATER. SEEK MEDICAL
ATTENTION. NEVER
GIVE LIQUIDS TO AN
UNCONSCIOUS PERSON.
INHALATION:
REMOVE TO FRESH AIR.
SUPPORT RESPIRATION
IF REQUIRED. SEEK
MEDICAL ATTENTION.
|
|
SECTION
VI - REACTIVITY
|
| STABILITY |
UNSTABLE |
|
CONDITIONS
TO AVOID |
| |
STABLE |
X |
NONE |
INCOMPATIBILITY (MATERIALS
TO AVOID)
STRONG
BASES,
METALS. |
HAZARDOUS
DECOMPOSITION
PRODUCTS
AMMONIA,
HYDROGEN GAS. |
HAZARDOUS
POLYMERIZATION |
MAY
OCCUR |
|
CONDITIONS
TO AVOID |
| WILL
NOT OCCUR |
X |
NONE
|
|
SECTION
VII - SPILL
OR LEAK PROCEDURES
|
| STEPS
TO BE TAKEN
IN CASE MATERIAL
IS RELEASED
OR SPILLED
FLUSH
INTO
A CHEMICAL
SEWER
OR SOAK
UP WITH
A SUITABLE
ABSORBENT.
|
| WASTE
DISPOSAL METHOD
DISPOSE
OF IN
ACCORDANCE
WITH
ALL LOCAL
STATE
AND FEDERAL
REGULATIONS.
|
|
SECTION
VIII - SPECIAL
PROTECTION
INFORMATION
|
| RESPIRATORY
PROTECTION
(Specify type)
ACID
MASK
REQUIRED
FOR FUMES
OVER
TLV.
|
| VENTILATION
LOCAL
EXHAUST
PREFERRED.
MECHANICAL
OK.
|
| PROTECTIVE
GLOVES
PLASTIC
OR RUBBER
|
EYE
PROTECTION
GOGGLES
OR FACE
SHIELD
|
| OTHER
PROTECTIVE
EQUIPMENT AND
HYGIENIC PRACTICES
AS
REQUIRED
TO AVOID
CONTACT.
|
|
SECTION
IX - SPECIAL
PRECAUTIONS
|
| PRECAUTIONS
TO BE TAKEN
IN HANDLING
AND STORING
DO
NOT STORE
OR USE
FROM
METALLIC
CONTAINERS.
|
| OTHER
PRECAUTIONS
AVOID
CONTACT.
|
| This
information
contained herein
is based on
data considered
accurate. However,
no warranty
is expressed
or implied
regarding the
accuracy of
this data or
the results
to be obtained
from the use
thereof. |
Print This Page