Print This Page

"Little Squirt" Penetrating Oil

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

"LITTLE SQUIRT" PENETRATING OIL

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS CAS# APPROX% ACGIH-TLV OSHA-PEL 
PETROLEUM DISTILLATES 8008-20-6 60-80 400 400
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIPPING PURPOSES.

 

 

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 2 0 - MINIMAL
FLAMMABILITY 2 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT A 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

LIGHT AMBER

 		ODOR

HYDROCARBON ODOR

 		BOILING POINT

314-392° F (CONCENTRATE)
SPECIFIC GRAVITY (H2O=1)

0.79

 		VAPOR PRESSURE (mm Hg.)

N/A

 		VOLATILE BY VOLUME (%)

>75%
VAPOR DENSITY (AIR=1)

N/A

 

 EVAPORATION RATE (BUAC=1)

N/A

 		SOLUBILITY IN WATER

NEG.

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
>120° F (TCC) (PERCENT BY VOLUME) 1 9.5
FIRE EXTINGUISHING MEDIA

CARBON DIOXIDE, FOAM, DRY CHEMICAL.
SPECIAL FIRE FIGHTING PROCEDURES

FIREFIGHTERS SHOULD USE SELF-CONTAINED POSITIVE PRESSURE BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARD

KEEP AWAY FROM IGNITION SOURCES AND OPEN FLAME.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY __X___Inhalation __X___Skin contact __X___Eye contact ______Ingestion
EFFECT OF OVEREXPOSURE

INHALATION: SHORTNESS OF BREATH, DIZZINESS, LIGHT HEADEDNESS. ANESTHETIC EFFECTS MAY OCCUR AT HIGH CONCENTRATIONS.

INGESTION: MAY CAUSE CHEMICAL PNEUMONIA IF ASPIRATED INTO LUNGS.

EYE CONTACT: POSSIBLE EYE IRRITANT.

SKIN CONTACT: SHORT CONTACT - NO IRRITATION. PROLONGED OR REPEATED CONTACT - MINOR TO MILD IRRITATION.

SKIN ABSORPTION: VERY LOW TOXICITY.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

NOT ESTABLISHED.
EMERGENCY AND FIRST AID PROCEDURES

EYES: FLUSH WITH WATER FOR 15 MINUTES OR UNTIL IRRITATION SUBSIDES.

SKIN: REMOVE ALL CONTAMINATED CLOTHING. WASH SKIN WITH SOAP AND WATER.

INHALATION: REMOVE FROM EXPOSURE IMMEDIATELY. IF BREATHING IS REGULAR OR STOPPED, BEGIN ARTIFICIAL RESPIRATION AND ADMINISTER OXYGEN.

INGESTION: DRINK LARGE AMOUNTS OF WATER. DO NOT INDUCE VOMITING.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X OPEN FLAMES, SPARKS, ELECTRICAL AREAS.
INCOMPATIBILITY (MATERIALS TO AVOID)
ALKALI MATERIALS, STRONG OXIDIZING AGENTS, STRONG ACIDS.
HAZARDOUS DECOMPOSITION PRODUCTS
THERMAL DECOMPOSITION MAY YIELD CARBON MONOXIDE AND CARBON DIOXIDE.
HAZARDOUS POLYMERIZATION MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN UP WITH INERT MATERIALS.
WASTE DISPOSAL METHOD

DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

RESPIRATORY PROTECTION PROGRAM SHOULD BE IN ACCORDANCE WITH 29 CFR 1910.134.
VENTILATION

LOCAL EXHAUST IS ADEQUATE.
PROTECTIVE GLOVES

POLYETHYLENE OR NEOPRENE

 		EYE PROTECTION

SAFETY GLASSES ARE RECOMMENDED.
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

PROTECTIVE CLOTHING AND EQUIPMENT.

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

DO NOT STORE IN DIRECT SUNLIGHT, NEAR OPEN FLAMES, OR AT TEMPERATURE EXCEEDING 120° F.

DO NOT SMOKE WHILE USING. USE ONLY AS DIRECTED.
OTHER PRECAUTIONS

NONE
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.