Print This Page

Marking Paint - Safety Red

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

 

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call
INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

MARKING PAINT - SAFETY RED

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS

CAS#

APPROX%

ACGIH-TLV-TWA

 OSHA-PEL-TWA
PROPANE 00074-98-6 20 1000 ppm 1000 ppm
N-BUTANE 00106-97-8 15 800 ppm 800 ppm
TOLUOL 00108-88-3 15 50 ppm 100 ppm
XYLENE 01330-20-7 10 100 ppm 100 ppm
VM&P NAPHTHA 64742-89-8 5 300 ppm 300 ppm
HEXANE 00110-54-3 5 50 ppm 50 ppm
ETHYL BENZENE 00100-41-4 5 100 ppm 100 ppm
MINERAL SPIRITS 64742-47-8 5 100 ppm 500 ppm
ACETONE 00067-64-1 5 500 ppm 750 ppm
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

CONSUMER COMMODITY ORM-D

SPECIAL HAZARD DESIGNATIONS
HMIS NFPA HAZARD RATING
HEALTH 1 1 0 - MINIMAL
FLAMMABILITY 3 3 1- SLIGHT
REACTIVITY 3 3 2- MODERATE
PROTECTIVE 3 3- SERIOUS

EQUIPMENT

 B 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

RED LIQUID		 ODOR

AROMATIC

 		BOILING RANGE

-44 TO 286° F
SPECIFIC GRAVITY (H2O=1)

0.8362

 		VAPOR PRESSURE (mm Hg.)

40 PSI

 		VOLATILE BY WEIGHT (%)

54%
VAPOR DENSITY (AIR=1)

IS HEAVIER THAN AIR.

 		EVAPORATION RATE (BUAC=1)

IS FASTER THAN ETHER.

 		SOLUBILITY IN WATER

SLIGHT

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
-9° F (PERCENT BY VOLUME) 0.7% 12.8%
FIRE EXTINGUISHING MEDIA

WATER FOG, DRY CHEMICAL, CO2, ALCOHOL FOAM, FOAM
SPECIAL FIRE FIGHTING PROCEDURES

CONTAINERS CAN BUILD UP PRESSURE IF EXPOSED TO HEAT (FIRE). AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND (MSHA/NIOSH APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
UNUSUAL FIRE AND EXPLOSION HAZARD

VAPORS MAY FORM EXPLOSIVE MIXTURE WITH AIR. FLAMMABILITY CLASSIFICATION, AS DEFINED BY 29 CFR 1910.1200: FLAMMABLE.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY __X____Inhalation ___X__Skin contact __X___Eye contact___X__Ingestion
EFFECT OF OVEREXPOSURE

INHALATION: HEADACHES, DIZZINESS, NAUSEA, DECREASED BLOOD PRESSURE, CHANGES IN HEART RATE AND CYANOSIS MAY RESULT FROM OVER-EXPOSURE TO VAPOR OR SKIN EXPOSURE. PROLONGED INHALATION MAY BE HARMFUL.

SKIN: CAUSES SKIN IRRITATION. ALLERGIC REACTIONS ARE POSSIBLE. PROLONGED OR REPEATED CONTACT CAN RESULT IN DEFATTING AND DRYING OF THE SKIN WHICH MAY RESULT IN SKIN IRRITATION AND DERMATITIS (RASH).

EYES: LIQUID, AEROSOLS AND VAPORS OF THIS PRODUCT ARE IRRITATING AND CAN CAUSE PAIN, TEARING, REDDENING AND SWELLING ACCOMPANIED BY A STINGING SENSATION AND/OR A FEELING LIKE THAT OF FINE DUST IN THE EYES.

INGESTION: THIS MATERIAL MAY BE HARMFUL OR FATAL IF SWALLOWED. IRRITATION TO MOUTH, THROAT AND STOMACH.
EMERGENCY AND FIRST AID PROCEDURES

EYES: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER. GET MEDICAL ATTENTION, IF IRRITATION PERSISTS.

SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.

INHALATION: RESCUERS SHOULD PUT ON APPROPRIATE PROTECTIVE GEAR. REMOVE FROM AREA OF EXPOSURE. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.

INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE VICTIM A GLASS OF WATER OR MILK. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.

SECTION VI - REACTIVITY
STABILITY UNSTABLE CONDITIONS TO AVOID

DO NOT STORE ABOVE 120 DEG. F. KEEP AWAY FROM SPARKS, PILOT LIGHTS, AND/OR OPEN FLAMES.
STABLE X
INCOMPATIBILITY (MATERIALS TO AVOID)
NO INFORMATION.
HAZARDOUS DECOMPOSITION PRODUCTS

MAY PRODUCE HAZARDOUS FUMES WHEN HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON DIOXIDE AND/OR CARBON MONOXIDE.
HAZARDOUS
POLYMERIZATION		 MAY OCCUR CONDITIONS TO AVOID

DO NOT STORE ABOVE 120 DEG. F. KEEP AWAY FROM SPARKS, PILOT LIGHTS, AND /OR OPEN FLAMES.
WILL NOT OCCUR X

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

ABSORB SPILL WITH INERT MATERIAL (E.G. DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL WASTE CONTAINER.
WASTE DISPOSAL METHOD

DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE, OR COMPACT. EMPTY CONTAINERS MUST BE HANDLED WITH CARE DUE TO PRODUCT RESIDUE. DO NOT HEAT OR CUT EMPTY CONTAINERS WITH ELECTRIC OR GAS TORCHES.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR CARTRIDGE OR CANISTER MAY BE PERMISSIBLE UNDER CERTAIN CIRCUMSTANCES WHERE AIRBORNE CONCENTRATIONS ARE EXPECTED TO EXCEED EXPOSURE LIMITS. PROTECTION PROVIDED BY AIR PURIFYING RESPIRATORS IS LIMITED. USE A POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL FOR AN UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT KNOWN, OR ANY OTHER CIRCUMSTANCES WHERE AIR PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE PROTECTION.
VENTILATION

LOCAL EXHAUST VENTILATION MAY BE NECESSARY TO CONTROL ANY AIR CONTAMINATES TO WITHIN THEIR TLVS DURING THE USE OF THIS PRODUCT.
PROTECTIVE GLOVES

RUBBER OR NEOPRENE GLOVES SHOULD BE WORN FOR PROLONGED OR REPEATED CONTACT.

 		EYE PROTECTION

WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES) AND A FACE SHIELD.
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

WHERE SPLASHING IS POSSIBLE, FULL CHEMICALLY RESISTANT PROTECTIVE CLOTHING (E.G. ACID SUIT) AND BOOTS ARE REQUIRED.

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

HANDLING: WASH THOROUGHLY AFTER HANDLING. USE WITH ADEQUATE VENTILATION. AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.

STORAGE: KEEP AWAY FROM HEAT, SPARKS AND FLAME. CONTENTS UNDER PRESSURE. DO NOT STORE ABOVE 120° F.
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.