|
SECTION I - GENERAL INFORMATION
|
Black
Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705 |
For chemical emergencies during
transportation only call
INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
|
| Date
Prepared
01/01/08
|
Trade
Name
Pipe Stick |
|
SECTION II - HAZARDOUS INGREDIENTS /
IDENTITY INFORMATION
|
| HAZARDOUS COMPONENTS |
CAS# |
APPROX% |
ACGIH-TLV |
OSHA-PEL |
|
| LINSEED OIL |
8001-26-1 |
10-20 |
5 mg/m3 AS
MIST |
|
|
| *Title
III Section 313 Supplier Notification: this product contains
toxic chemicals subject to the reporting requirements
of Section 313 of the Emergency planning and community
Right-to-Know Act of 1966 and of 40CFR372. This information
must be included in all MSDS’s that are copied and distributed
for this material. |
|
SHIPPING INFORMATION
NOT HAZARDOUS FOR SHIPPING PURPOSES.
|
SPECIAL HAZARD DESIGNATIONS
| HEALTH |
1 |
1 |
0 - MINIMAL |
| FLAMMABILITY |
1 |
1 |
1- SLIGHT |
| REACTIVITY |
0 |
0 |
2- MODERATE |
| PROTECTIVE |
|
|
3- SERIOUS |
| EQUIPMENT |
|
|
4- SEVERE |
|
|
SECTION III - PHYSICAL DATA
|
| APPEARANCE
WHITE SOLID
|
ODOR
FAINT FATTY ODOR
|
BOILING
POINT
ABOVE 500° F
|
| SPECIFIC
GRAVITY (H2O=1)
0.9
|
VAPOR
PRESSURE (mm Hg.)
N/A
|
VOLATILE
BY VOLUME (%)
NEGLIGIBLE
|
| VAPOR
DENSITY (AIR=1)
N/A
|
EVAPORATION
RATE (BUAC=1)
NEGLIGIBLE
|
SOLUBILITY
IN WATER
NOT SOLUBLE
|
|
SECTION IV - FIRE AND EXPLOSION HAZARD
DATA
|
| FLASH
POINT ( METHOD USED) |
FLAMMABLE
LIMITS |
LEL |
UEL |
OVER
300° |
(PERCENT
BY VOLUME) |
N/A |
N/A |
| FIRE
EXTINGUISHING MEDIA
CO2, DRY CHEMICAL
|
| SPECIAL
FIRE FIGHTING PROCEDURES
WATER FOG AND FOAM MAY CAUSE FROTHING. DIRECT WATER
STREAM WILL SPREAD FLAMES. USE WATER FOG TO KEEP CONTAINERS
COOL.
|
| UNUSUAL
FIRE AND EXPLOSION HAZARD
PRODUCTS OF COMBUSTION MAY BE TOXIC. FIRE FIGHTING
PERSONNEL SHOULD EMPLOY POSITIVE PRESSURE BREATHING APPARATUS..
|
|
SECTION V - HEALTH HAZARD DATA
|
PRIMARY
ROUTES OR ENTRY ______Inhalation
__X__Skin contact __X__Eye contact ______Ingestion
|
| EFFECT
OF OVEREXPOSURE
LOW ORDER OF TOXICITY. MAY CAUSE REVERSIBLE EYE AND
SKIN IRRITATION. PROLONGED EXPOSURE MAY CAUSE OIL,
ACNE OR DERMATITIS.
|
| MEDICAL
CONDITIONS AGGRAVATED BY EXPOSURE
BREATHING MISTS MAY CAUSE DIZZINESS OR PULMONARY IRRITATION.
|
| EMERGENCY
AND FIRST AID PROCEDURES
IN ALL CASES REMOVE SOURCE OF EXPOSURE.
|
|
SECTION VI - REACTIVITY
|
| STABILITY |
UNSTABLE |
|
CONDITIONS
TO AVOID |
| |
STABLE |
X |
NOT
APPLICABLE |
INCOMPATIBILITY (MATERIALS
TO AVOID)
STRONG OXIDIZERS |
HAZARDOUS
DECOMPOSITION PRODUCTS
CO, CO2, AND OTHER COMBUSTION PRODUCTS OF HYDROCARBONS |
| HAZARDOUS
POLYMERIZATION |
MAY
OCCUR |
|
CONDITIONS
TO AVOID |
| WILL
NOT OCCUR |
X |
NOT
APPLICABLE |
|
SECTION VII - SPILL OR LEAK PROCEDURES
|
| STEPS
TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
EXTINGUISH IGNITION SOURCES. KEEP OUT OF WATERWAYS.
|
| WASTE
DISPOSAL METHOD
DISPOSE IM ACCORDANCE WITH ALL REGULATIONS. MATERIAL
MAY BE CLASSED AS HAZARDOUS THROUGH USE. INCINERATION
MAY BE PERMISSIBLE. CONSIDER RECYCLING.
|
|
SECTION VIII - SPECIAL PROTECTION INFORMATION
|
| RESPIRATORY
PROTECTION (Specify type)
NOT NORMALLY REQUIRED.
|
| VENTILATION
GENERAL AREA.
|
| PROTECTIVE
GLOVES
OIL RESISTANT.
|
EYE
PROTECTION
SAFETY GLASSES OR SPLASH GOGGLES.
|
| OTHER
PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES
IF CONTACT IS LIKELY, AN OIL RESISTANT APRON AND SHOES
SHOULD BE WORN TO PREVENT PROLONGED CONTACT.
|
|
SECTION IX - SPECIAL PRECAUTIONS
|
| PRECAUTIONS
TO BE TAKEN IN HANDLING AND STORING
KEEP AWAY FROM FLAMES, SPARKS OR HOT SURFACES. DO NOT
USE A TORCH TO CUT OR WELD NEAR CONTAINER.
|
| OTHER
PRECAUTIONS
CLOTHING SOILED BY THIS PRODUCT SHOULD
BE LAUNDERED PRIOR TO REUSE. PREVENT EYE CONTACT.
AVOID PROLONGED SKIN CONTACT. |
| This
information contained herein is based on data considered
accurate. However, no warranty is expressed or implied
regarding the accuracy of this data or the results
to be obtained from the use thereof. |
Print This Page