Print This Page

Powdered Boiler Stop-Leak

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700

Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC

1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name

POWDERED BOILER STOP-LEAK

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS         CAS#          APPROX%           ACGIH-TLV           OSHA-PEL
THIS PRODUCT IS NOT CLASSIFIED AS HAZARDOUS IN ACCORDANCE WITH OSHA 1910.1200.
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIIPPINGPURPOSES.

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 1 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT  E 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

GRAYISH SILVER POWDER

 		ODOR

SLIGHT

 		BOILING POINT

N/A
SPECIFIC GRAVITY (H2O=1)

.45

 		VAPOR PRESSURE (mm Hg.)

N/A

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

N/A

 		EVAPORATION RATE (BUAC=1)

N/A

 		SOLUBILITY IN WATER

SLIGHTLY

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
N/A (PERCENT BY VOLUME) N/A N/A
FIRE EXTINGUISHING MEDIA

WATER, DRY CHEMICAL, CARBON DIOXIDE.
SPECIAL FIRE FIGHTING PROCEDURES

WEAR SELF-CONTAINED POSITIVE PRESSURE BREATHING APPARATUS AND PROTECTIVE CLOTHING.
UNUSUAL FIRE AND EXPLOSION HAZARD

CONTAINS ALUMINUM POWDER WHICH COULD FORM FLAMMABLE AND EXPLOSIVE MIXTURE IN AIR.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY __X___Inhalation __ __Skin contact __ __Eye contact _____Ingestion
EFFECT OF OVEREXPOSURE

INHALATION OF DUST MAY IRRITATE THE NOSE AND THROAT. MAY BE HARMFUL IF SWALLOWED. EYE AND SKIN IRRITANT.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

NONE KNOWN
EMERGENCY AND FIRST AID PROCEDURES

INHALATION: IF OVERCOME BY EXPOSURE, REMOVE TO FRESH AIR IMMEDIATELY. GIVE OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED. OBTAIN EMERGENCY MEDICAL ATTENTION.

EYES: IN CASE OF EYE CONTACT, IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. OBTAIN MEDICAL ATTENTION IF IRRITATION PERSIST.

SKIN: REMOVE CONTAMINATED CLOTHING AS NEEDED. WASH SKIN THOROUGHLY WITH MILD SOAP AND WATER. OBTAIN MEDICAL ATTENTION IF IRRITATION DEVELOPS.

INGESTION: IF SWALLOWED INDUCE VOMITING. OBTAIN EMERGENCY MEDICAL ATTENTION.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X HIGH HEAT AND OPEN FLAME.
INCOMPATIBILITY (MATERIALS TO AVOID)
STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS
NONE.
HAZARDOUS POLYMERIZATION MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

PHYSICALLY SWEEP UP AND PLACE INTO CONTAINER.
WASTE DISPOSAL METHOD

LANDFILL OR SIMILAR. MATERIAL IS BIODEGRADABLE.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

FACE MASK IF DUSTY CONDITIONS OCCUR.
VENTILATION

NONE
PROTECTIVE GLOVES

RUBBER GLOVES

 		EYE PROTECTION

SAFETY GLASSES
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

USE GOOD PERSONAL HYGIENE PRACTICES. WASH THOROUGHLY AFTER HANDLING.

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

STORE IN DRY AREA. AVOID MOISTURE AND EXCESSIVE HEAT TO MAINTAIN PRODUCT QUALITY.
OTHER PRECAUTIONS

KEEP OUT OF REACH OF CHILDREN.
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.