Print This Page

Powdered Form Boiler Cleaner

Material Safety Data Sheet

Information on this form is furnished solely for the purpose of compliance with the Occupational Safety and Health Act and shall not be used for any other purpose. Black Swan Manufacturing Co. urges the customers receiving this Material Safety Data Sheet to study it carefully to become aware of the hazards, if any, of the product involved. In the interest of safety, you should notify your employees, agents, and contractors of the information on the sheet.

SECTION I - GENERAL INFORMATION
Black Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705

For chemical emergencies during
transportation only call

INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
Date Prepared

01/01/08

 		Trade Name
 Powdered Form Boiler Cleaner

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
HAZARDOUS COMPONENTS                 CAS#          APPROX%             ACGIH-TLV           OSHA-PEL
THIS PRODUCT IS NOT CLASSIFIED AS HAZARDOUS IN ACCORDANCE WITH OSHA 1910.1200.
*Title III Section 313 Supplier Notification: this product contains toxic chemicals subject to the reporting requirements of Section 313 of the Emergency planning and community Right-to-Know Act of 1966 and of 40CFR372. This information must be included in all MSDS’s that are copied and distributed for this material.

SHIPPING INFORMATION

NOT HAZARDOUS FOR SHIPPING PURPOSES.

SPECIAL HAZARD DESIGNATIONS

HMIS HAZARD RATING
HEALTH 1 0 - MINIMAL
FLAMMABILITY 0 1- SLIGHT
REACTIVITY 0 2- MODERATE
PROTECTIVE 3- SERIOUS
EQUIPMENT C 4- SEVERE

SECTION III - PHYSICAL DATA
APPEARANCE

YELLOW POWDERED COMPOUND

 		ODOR

FAINT

 		BOILING POINT

DECOMP. 210-215° F
SPECIFIC GRAVITY (H2O=1)

1

 		VAPOR PRESSURE (mm Hg.)

N/A

 		VOLATILE BY VOLUME (%)

N/A
VAPOR DENSITY (AIR=1)

N/A

 EVAPORATION RATE (BUAC=1)

N/A

 		SOLUBILITY IN WATER

PARTIAL SOLUBILITY

SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT ( METHOD USED) FLAMMABLE LIMITS LEL UEL
N/A (PERCENT BY VOLUME) N/A N/A
FIRE EXTINGUISHING MEDIA

WATER, FOAM, DRY CHEMICAL.
SPECIAL FIRE FIGHTING PROCEDURES

WATER SPRAY MAY BE USED TO COOL FIRE-EXPOSED CONTAINERS.
UNUSUAL FIRE AND EXPLOSION HAZARD

NONE.

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTES OR ENTRY __X___Inhalation ______Skin contact ______Eye contact ______Ingestion
EFFECT OF OVEREXPOSURE

NONE.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE

NONE ESTABLISHED.
EMERGENCY AND FIRST AID PROCEDURES

EYES: FLUSH 15 MINUTES WITH WATER.

SKIN: WASH THOROUGHLY WITH SOAP & WATER.

SEE PHYSICIAN IF CONTACT IS MADE WITH OPEN SORES.

SECTION VI - REACTIVITY
STABILITY UNSTABLE   CONDITIONS TO AVOID
  STABLE X PRECIPITATES WITH SALTS OF HEAVY METALS.
INCOMPATIBILITY (MATERIALS TO AVOID)
ALKALOID, GELATIN, ALBUMIN & STARCH.
HAZARDOUS DECOMPOSITION PRODUCTS
NONE.
HAZARDOUS
POLYMERIZATION		 MAY OCCUR   CONDITIONS TO AVOID
WILL NOT OCCUR X NONE

SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED

SWEEP UP & WASH AREA WITH WATER.
WASTE DISPOSAL METHOD

DISPOSE IN LANDFILL IN ACCORDANCE WITH GOVERNMENTAL REGULATIONS.

SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Specify type)

U.S. BUREAU OF MINES RESPIRATOR FOR NUISANCE DUSTS.
VENTILATION

LOCAL EXHAUST IS ADEQUATE.
PROTECTIVE GLOVES

WEAR RUBBER GLOVES.

 		EYE PROTECTION

WEAR SAFETY GOGGLES.
OTHER PROTECTIVE EQUIPMENT AND HYGIENIC PRACTICES

NONE REQUIRED FOR NORMAL USE.

SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING

DRY STORAGE.
OTHER PRECAUTIONS

NONE REQUIRED FOR NORMAL USE.
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.