|
SECTION I - GENERAL INFORMATION
|
Black
Swan Manufacturing Co.
4540 W. Thomas Street
Chicago, IL 60651-3318
Telephone No: 1-773-227-3700
Fax No: 1-773-227-3705 |
For chemical emergencies during
transportation only call
INFOTRAC
1-800-535-5053
24 hours per day - 7 days a week
|
| Date Prepared
01/01/08
|
Trade Name
FURNACE & RETORT CEMENT
|
|
SECTION II - HAZARDOUS INGREDIENTS / IDENTITY
INFORMATION
|
| HAZARDOUS COMPONENTS |
CAS# |
APPROX% |
ACGIH-TLV |
OSHA-PEL |
|
| LIQUID SODIUM SILICATE |
1344-09-8 |
10-20 |
TLV=2mg/m3 |
PEL=2mg/m3 |
|
| *Title III Section 313
Supplier Notification: this product contains toxic chemicals
subject to the reporting requirements of Section 313 of the
Emergency planning and community Right-to-Know Act of 1966 and of
40CFR372. This information must be included in all MSDS’s that
are copied and distributed for this material. |
|
SHIPPING INFORMATION
NOT HAZARDOUS FOR SHIPPING PURPOSES.
|
SPECIAL HAZARD DESIGNATIONS
|
HEALTH |
2 |
0 - MINIMAL |
| FLAMMABILITY |
0 |
1- SLIGHT |
| REACTIVITY |
0 |
2-MODERATE |
| PROTECTIVE |
|
3- SERIOUS |
| EQUIPMENT |
A |
4- SEVERE |
|
|
SECTION III - PHYSICAL DATA
|
| APPEARANCE
GRAY TO BLACK
|
ODOR
ODORLESS MORTAR
|
BOILING
POINT
N/A
|
| SPECIFIC
GRAVITY (H2O=1)
1.75
|
VAPOR
PRESSURE (mm Hg.)
N/A
|
VOLATILE
BY VOLUME (%)
N/A
|
| VAPOR
DENSITY (AIR=1)
N/A
|
EVAPORATION
RATE (BUAC=1)
N/A
|
SOLUBILITY
IN WATER
SLIGHTLY SOLUBLE IN WATER AN WATER MISCIBLE.
|
|
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
|
| FLASH POINT (
METHOD USED) |
FLAMMABLE
LIMITS |
LEL |
UEL |
| N/A |
(PERCENT BY VOLUME) |
N/A |
N/A |
| FIRE EXTINGUISHING
MEDIA
NON-FLAMMABLE. USE APPROPRIATE MEANS FOR SURROUNDING AREA.
|
| SPECIAL FIRE FIGHTING
PROCEDURES
NONE
|
| UNUSUAL FIRE AND
EXPLOSION HAZARD
NONE
|
|
SECTION V - HEALTH HAZARD DATA
|
| PRIMARY ROUTES OR ENTRY ______Inhalation
__X___Skin contact __X___Eye contact ______Ingestion
|
| EFFECT OF
OVEREXPOSURE
PROLONGED CONTACT WITH SKIN CAN CAUSE IRRITATION. CONTACT WITH
EYES OR OPEN ABRADED SKIN CAN CAUSE SEVERE IRRITATION WITH
SUPERFICIAL DESTRUCTION OF SKIN TISSUE.
|
| MEDICAL CONDITIONS
AGGRAVATED BY EXPOSURE
OPEN SORES AND CUTS—SENSITIVE SKIN AREAS.
|
| EMERGENCY AND FIRST
AID PROCEDURES
SKIN: WASH AFFECTED AREAS WITH SOAP AND WATER.
INGESTION: DO NOT INDUCE VOMITING, DILUTE WITH WATER OR
MILK, GET MEDICAL ATTENTION.
EYES: FLUSH THE MATERIAL OUT IMMEDIATELY WITH PLENTY OF
WATER.
|
|
SECTION VI - REACTIVITY
|
| STABILITY |
UNSTABLE |
|
CONDITIONS TO AVOID |
| |
STABLE |
X |
KEEP AWAY FROM ACIDS. |
INCOMPATIBILITY (MATERIALS
TO AVOID)
ACIDS, ANHYDRIDES, ALKALI METALS,
ANHYDROUS ALUMINIUM CHLORIDE NON FERROUS METALS AFTER SETTING. |
HAZARDOUS
DECOMPOSITION PRODUCTS
SHARP EDGES AFTER DRYING OR FIRING. |
HAZARDOUS
POLYMERIZATION |
MAY OCCUR |
|
CONDITIONS TO AVOID |
| WILL NOT OCCUR |
X |
NONE |
|
SECTION VII - SPILL OR LEAK PROCEDURES
|
| STEPS TO BE TAKEN IN
CASE MATERIAL IS RELEASED OR SPILLED
MATERIAL IS IN PASTE FORM. USE ABSORBENT MATERIAL AND SWEEP UP.
|
| WASTE DISPOSAL METHOD
DISCARD AS NON-HAZARDOUS WASTE.
|
|
SECTION VIII - SPECIAL PROTECTION INFORMATION
|
| RESPIRATORY
PROTECTION (Specify type)
NONE REQUIRED.
|
| VENTILATION
LOCAL EXHAUST - ADEQUATE.
|
| PROTECTIVE GLOVES
RUBBER GLOVES
|
EYE PROTECTION
GOGGLES
|
| OTHER PROTECTIVE
EQUIPMENT AND HYGIENIC PRACTICES
NORMAL WORKING CLOTHING. PRACTICE NORMAL SAFETY AND HEALTH
PROCEDURES.
WASH THOROUGHLY AFTER HANDLING.
|
|
SECTION IX - SPECIAL PRECAUTIONS
|
| PRECAUTIONS TO BE
TAKEN IN HANDLING AND STORING
NORMAL SHELF STORAGE.
|
| OTHER PRECAUTIONS
NONE
|
| This information
contained herein is based on data considered accurate. However, no
warranty is expressed or implied regarding the accuracy of this
data or the results to be obtained from the use thereof. |
Print This Page